2004 and Prior Model Year Saturn Vehicles
In order to access this bulletin electronically, go to the SI Home Page (http://service.gm.com) and select the "Latest News" icon. The documents are arranged by sub-section and then by date (newest to oldest). Scroll down to "General Information" then click on the latest "Field Product Reminder" bulletin.
Model Year(s) | Vehicle Line(s) / Condition | Do This | Don't Do This | Reference Information/Bulletin |
|---|---|---|---|---|
2002-2003 | VUE Vehicles with 2.2L 4-Cylinder Engine - Check Engine Light on with P0440 or P0442 Stored | Verify no EVAP leaks using the service manual procedure. If no leaks are identified, reprogram the ECM with the calibration available on Saturn Service Stall data release TIS 8.0 2004 or later. | Don’t replace EVAP components. | 04-06-04-033A |
2002 | VUE Vehicles with 2.2L 4-Cylinder Engine - Check Engine Light On with P0606 after ECM programming | Reprogram the ECM again with the calibration available on Saturn Service Stall data release TIS 8.0 2004 or later. | Don't replace the ECM. | Saturn Service Stall release notes for data release TIS 8.0 2004 |
2003-2004 | ION Built Up To and Including VIN Breakpoint 4Z211388 - Temperature/Mode Control Knobs May Not Rotate, Air Flow Restricted, or HVAC Mode Door Gasket or Temperature Door Gasket Foam Comes Off | Replace A/C Evaporator Case/Heater Case Assembly. | Don’t replace or attempt to reattach the foam gasket. | 04-01-38-011 |
2002-2004 | VUE with All Wheel Drive (RPO GQ1) Built Prior to VIN Breakpoint 4S853184 - Vibration Felt in Seatback or Armrest at Vehicle Speeds Between 30 to 55 mph | Replace Propeller Shaft Center Support Bearing. | Don’t replace the propeller shaft. | 04-04-17-002 |
2004 | ION Red Line Coupe with 2.0 L LSJ Engine - Engine Cranks With No Start or Engine has Extended Crank (Greater than 3 Seconds) Before Starting | Verify the timing of the camshaft position trigger and adjust if necessary. | Don’t replace fuel pump or other ignition related components. | 04-06-01-026 |
2004 | ION and VUE with Single-Disc CD Player (RPO U1C) - Popping/Crackling Noise or Distorted Sound from Speakers at Low Volume When a CD Is Played. This information also applies to any Saturn vehicle with service CD player (P/N 22711669) installed. | Replace CD player/radio with P/N 21997420. | Don’t replace CD player/radio with any other radio part number. | 04-08-44-016 |
2004 | VUE AWD with 3.5 L L66 Engine - Moan/Growl Noise/Vibration from Rear of Vehicle when Turning at Low Speeds | Replace Rear Drive Module Differential Clutch Drum with P/N 15235314. | Don’t replace RDM clutch drum with any other part number. | Reference parts catalog. |
2002-2003 | VUE - Air Conditioning (A/C) Compressor Inoperative withVehicle Speed | Disconnect and inspect instrument panel/body inline connector (black 40-pin electrical connector) and replace damaged terminals and/or apply dielectric grease to connector. | Don’t replace compressor, HVAC control head or other a/c components. | 03-08-45-003A |
1991-2005 | All Saturn Vehicles - Pinstripe/Vinyl Graphic Installation Tips and Techniques | Follow tips and techniques as outlined in bulletin 04-08-51-004. | Don't use any aromatic solvents such as acetone, M.E.K., toluene, paint thinner, lacquer thinner on the pinstripes/vinyl graphics. Don't overcoat the pinstripes/vinyl graphics with clear paint. Don't apply wax over pinstripes/vinyl graphics. | 04-08-51-004 |
2003-2004 | ION Coupes - Gap Is Present Between the Front Fascia and Headlamp Assembly During Times of High Ambient Temperatures and Maximum Thermal Growth | Replace fascia with P/N 15207535. | Don't attempt other repair. | Reference ESI "Preliminary Information" PIC3105. |
Category Type | Subject | Model(s) | Model Year(s) | Bulletin Number |
|---|---|---|---|---|
Body & Accessories | Reduced Power, Stuck in High Gear, Service Engine Soon (SES) Light On, DTCs P0223, P0504, P0700, P1228, P1271, P1280, P1599, P1779, P1791, P2119, P2101, P2128, P2135, or P2138 Set, Buzz Noise from Door Speakers or Door Speakers Inoperative, Heating-Ventilation-Air Conditioning (HVAC) Blower Motor Inoperative and/or Air Conditioning (A/C) Compressor Inoperative with Vehicle Speed (Inspect/Replace Corroded or Bent Terminals) | VUE | 2002-2003 | 03-08-45-003A |
Body & Accessories | Headliner Material (Fabric) Sagging or Separating from Substrate (Replace Headliner) | ION Quad Coupe | 2004 | 04-08-110-006 |
Body & Accessories | Popping/Crackling Noise or Distorted Sound from Speakers at Low Volume When a Compact Disc (CD) Is Played (Replace RPO U1C CD Player/Radio with New Design CD Player/Radio) | VUE & ION This bulletin also applies to any Saturn vehicle with service CD player, P/N 22711669, installed | 2004 | 04-08-44-016 |
Body & Accessories | Squeak/Itch Noise from Rear Seat When Driving on Rough Surfaces (Apply Squeak Reduction Tape to Striker) | ION | 2003-3005 | 04-08-50-013 |
Body & Accessories | Pinstripe/Vinyl Graphic Installation Tips and Techniques | All Saturn vehicles | 1991-2005 | 04-08-51-004 |
Body & Accessories | Fuel Gauge Displays an Erratic or False Reading or No Start Condition after Vehicle is Shut Off with Low Fuel Level (Diagnose Fuel Gauge and Fuel Sender and/or Adjust/Replace Fuel Sender) | L-Series | 2000-2005 | 03-08-49-022A |
Body & Accessories | Wind Noise at Highway Speeds from Base of Driver Side (Left) A-Pillar Near VIN Plate Area (Seal Area with Seam Sealer) | VUE | 2003-2004 | 03-08-58-05A |
Driveline Axle | Vibration Felt in Seatback or Armrest at Vehicle Speeds Between 48 to 89 km/h (30 to 55 mph) (Replace Propeller Shaft Center Support Bearing) | VUE w/ RPO GQ1 and VIN Break | 2002-2004 | 04-04-17-002 |
Engine /Propulsion System | Engine Cranks With No Start or Engine has Extended Crank (Greater than 3 Seconds) Before Starting (Verify the Timing of the Camshaft Position Trigger and Adjust if Necessary) | ION Red Line Coupe | 2004 | 04-06-01-026 |
HVAC | Water Leaks into Passenger Compartment Through HVAC Module Condensate Drain Tube When Parked on Incline/Uphill Position (Install Auxiliary Drain Tube Extension) | ION Sedans and Coupes | 2003-2004 | 03-01-39-011A |
HVAC | Temperature/Mode Control Knobs May Not Rotate, Air Flow Restricted, or HVAC Mode Door gasket or Temperature Door Gasket Foam Comes Off (Replace A/C Evaporator Case/Heater Case Assembly) | ION w/ VIN Break | 2003-2004 | 04-01-38-011 |
Suspension | Steering Wheel Shake or Vibration at 100 to 109 km/h (62 to 69 mph) (Follow Vibration Complaint Flow Chart/Replace Hub Assembly, If Necessary) | S-Series | 2000-2002 | 04-03-10-008 |
Suspension | Creaking/Squeaking Noise From the Front Suspension When Turning the Steering Wheel (Replace Front Strut Bumper) | ION | 2003-2004 | 04-03-08-013 |
Suspension | Vehicle Vibrations at Highway Speeds 72 to 110 km/h (45 to 79 mph) (Road Test Vehicle/Perform Diagnostic Procedures, If Necessary) | ION | 2004-2005 | 04-03-10-006 |
Transmission/ Transaxle | Grind/Rattle Noise from Transaxle in Park or Neutral After an Extended Cold Soak Following Case Cover Replacement or Other Internal Transaxle Overhaul (Replace VT25E Transaxle Assembly) | ION and VUE | 2003-2004 | 04-07-30-032 |
Model Year(s) | Component on Restriction | Reference Info/Bulletin/Phone Number |
|---|---|---|
2004 | Saturn VUE MJ7/MJ8 Automatic Transmission Assemblies | Bulletin # 03-07-30-040 Saturn Technical Assistance Center 1-800-828-2112, prompt 1, (Canada English 1-800-263-7740, Canada French 1-800-263-7960) |
2004 | Saturn ION Supercharged 2.0L LSJ Ecotec Engine | Bulletin #04-06-01-014 Saturn Technical Assistance Center 1-800-828-2112, prompt 1, (Canada English 1-800-263-7740, Canada French 1-800-263-7960) |
|
GM bulletins are intended for use by professional technicians,
NOT a "do-it-yourselfer". They are written to inform these
technicians of conditions that may occur on some vehicles, or to
provide information that could assist in the proper service of a
vehicle. Properly trained technicians have the equipment,
tools, safety instructions, and know-how to do a job properly and
safely. If a condition is described, DO NOT assume that the
bulletin applies to your vehicle, or that your vehicle will have
that condition. See your GM dealer for information on whether
your vehicle may benefit from the information. |
|
WE SUPPORT VOLUNTARY TECHNICIAN CERTIFICATION |
© Copyright General Motors Corporation. All Rights Reserved.